Building shelves on plaster walls quotes,free wooden futon frame plans 2014,instructions for building coffee table,bancobet terminal - PDF Review

22.12.2015
ManMade reader Ruben van Dijk sent us his most recent DIY project: a set of stylish concrete shelves. When looking for extra storage space in a garage, basement or out building wall shelving can often be your best option. The thought of fastening a simple set of shelves to rock-hard concrete might dismay the average do-it-yourselfer. His girlfriend had asked for a clean and simple solution for displayingher camerasand Ruben knew concrete would be the way to go. When the walls are made of masonry or concrete it may appear to be more difficult to install shelving, but through the following steps you can hang shelves directly onto the concrete or masonry wall just as easily as on a wood framed wall. Place a pencil mark where each shelf will start, and use a 4-foot level to mark a pencil line across the length of the wall at each height.
You can purchase pre-cut shelf boards at most hardware stores that are already covered with a laminate surface.
Place a shelf board across the brackets so that it is flush to the wall and even to your edge lines on both sides. Unless you plan to store very heavy objects on your shelves you will need to install a bracket at both ends and around every two feet along the length of the shelf. To get the best strength for your money use reinforced support steel brackets that can be found at hardware stores or home improvement stores.


He was totally right. Ruben crafted the whole thing from scratch, using floating shelf brackets and custom plywood molds. Measure from one end of the proposed shelf line and mark each 24 inches with a pencil line.
Hold the first bracket up to the wall so that the top is even with your shelf line and the mounting holes line up with the holes you drilled.
In most cases you will need to cut your shelf board at least for length if not also for width.
Once you are satisfied with the layout of the shelf, use an electric screwdriver to drill mounting screws (be sure that the length of the screw is less than the depth of the shelf board) through the underside of the top of the brackets into the bottom of the shelf board. If the line comes into contact with a seam in the concrete or a mortar line in the brick, move your mark a few inches over.
Hold a mounting bracket against the wall so that the top is even with the shelf line at the point you marked for a bracket. Holding your drill level, drill a hole into each spot you marked for mounting your shelves to the depth of the mark on your bit. If you are using expanding nails, hammer the nail until it is flush with the casing and tight to the wall. If your masonry wall is multiple layers thick with a air pocket between each layer you can drill through the first run of brick and use toggle bolts to attach through to the back of the brick.


Using your measuring tape and a pencil mark your length and width on the wood you are using for the shelving. Use your 4 foot level to make sure each bracket is level with the next before firmly installing. Using a table saw or a circular saw with a guide and cut your shelf section to length and width.
If you are making several shelves of the same size you can save time by using the first cut shelf as a template for the rest. Once the cuts are made use a low grit sandpaper (150 grit or less) to remove splinters and jagged edges.
Underneath you can use boxes or creates and the middle shelf is perfect for storing books.View in galleryFor the living room, you can also make something like this.
Use them to raise the bed and take the opportunity to also get some extra storage space for things like shoes or other small items. You can also use them separately as individual planters.View in galleryMake a concrete block planter wall and give it any shape you want.



Build outdoor sectional 2x4
Wood planter box bulk
Bookshelf door plans


Comments to “Building shelves on plaster walls quotes”

  1. uyda writes:
    Loved working with blah.UNCONSCIOUS SELF began out framing houses and up/down.
  2. KahveGozlumDostum writes:
    Mud removal system woodworking shop.